 |
|
| If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
|
|
| If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
|
| Datasheet File OCR Text: |
| PM800HSA120 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 IntellimodTM Module Half Phase IGBT Inverter Output 800 Amperes/1200 Volts A D BB TYP DD R (2 REQD) AA E B X 12 3 4 5 W S (4 HOLES) T F CC V SQ.(5 PLACES) TYP TYP Q K L M H J G N VI 1 Rref 1.5 OHM Rfo FO 5 SR 2 CI 3 C1 300 pf FO SR IN GND VCC TEMP OUT1 OUT2 SENS SINK AMP C VC 4 Outline Drawing and Circuit Diagram Dimensions A B C D E F G H J K L M N P Inches 3.94 5.20 Millimeters 100.0 132.0 Dimensions Q R S T U V W X AA BB CC DD Inches 0.10 M8 Metric O 6.5 1.02 0.26 0.025 0.20 1.97 0.71 0.55 0.39 1.14. Millimeters 2.54 M8 O 6.5 26.0 6.5 0.64 5.0 50.0 18.0 14.0 10.0 29.0 1.33 +0.04/-0.02 33.7 +1.0/-0.5 3.230.010 4.330.010 2.84 1.42 0.53 0.06 0.17 0.15 0.06 0.35 0.53 82.00.25 110.00.25 72.0 36.0 13.5 1.5 4.4 3.8 1.5 9.0 13.5 E P C C Description: Powerex IntellimodTM Intelligent Power Modules are isolated base modules designed for power switching applications operating at frequencies to 20kHz. Built-in control circuits provide optimum gate drive and protection for the IGBT and free-wheel diode power devices. Features: Complete Output Power Circuit Gate Drive Circuit E Tm Protection Logic - Short Circuit - Over Current - Over Temperature - Under Voltage Applications: Inverters UPS Motion/Servo Control Power Supplies Ordering Information: Example: Select the complete part number from the table below -i.e. PM800HSA120 is a 1200V, 800 Ampere IntellimodTM Intelligent Power Module. Type PM Current Rating Amperes 800 VCES Volts (x 10) 120 1 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM800HSA120 IntellimodTM Module Half Phase IGBT Inverter Output 800 Amperes/1200 Volts Absolute Maximum Ratings, Tj = 25C unless otherwise specified Characteristics Power Device Junction Temperature Storage Temperature Case Operating Temperature Mounting Torque, M6 Mounting Screws Mounting Torque, M8 Main Terminal Screws Module Weight (Typical) Supply Voltage Protected by OC and SC (VD = 13.5 - 16.5V, Inverter Part) Isolation Voltage, AC 1 minute, 60Hz Sinusoidal Symbol Tj Tstg TC -- -- -- VCC(prot.) VRMS PM800HSA120 -20 to 150 -40 to 125 -20 to 100 26 95 1700 800 2500 Units C C C in-lb in-lb Grams Volts Volts Control Sector Supply Voltage Applied between (V1-VC) Input Voltage Applied between (C1-VC) Fault Output Supply Voltage (Applied between Fo-Vc) Fault Output Current VD VCIN VFO IFO 20 10 20 20 Volts Volts Volts mA IGBT Inverter Sector Collector-Emitter Voltage (VD = 15V, VCIN = 5V) Collector Current, Peak Collector Current, Collector Dissipation VCES IC ICP PC 1200 800 1600 4630 Volts Amperes Amperes Watts 2 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM800HSA120 IntellimodTM Module Half Phase IGBT Inverter Output 800 Amperes/1200 Volts Electrical and Mechanical Characteristics, Tj = 25C unless otherwise specified Characteristics Symbol Test Conditions Min. Typ. Max. Units Control Sector Over Current Trip Level Inverter Part Short Circuit Trip Level Inverter Part Over Current Delay Time Over Temperature Protection OC SC toff(OC) OT OTR Supply Circuit Under Voltage Protection UV UVR Supply Voltage Circuit Current Input ON Threshold Voltage Input OFF Threshold Voltage PWM Input Frequency Fault Output Current VD ID VCIN(on) VCIN(off) fPWM IFO(H) IFO(L) Minimum Fault Output Pulse Width SXR Terminal Output Voltage tFO VSXR -20C Tj 125C -20C Tj 125C VD = 15V Trip Level Reset Level Trip Level Reset Level Applied between V1-VC VD = 15V, VCIN = 5V, V1-VC Applied between C1-VC Applied between C1-VC 3-O Sinusoidal VD = 15V, VFO = 15V VD = 15V, VFO = 15V VD = 15V Tj 125C, Rin = 6.8 k 1060 1350 -- 100 85 11.5 -- 13.5 -- 1.2 1.7 -- -- -- 1.0 4.5 1300 1700 5 110 95 12.0 12.5 15 23 1.5 2.0 15 -- 10 1.8 5.1 -- -- -- 120 105 12.5 -- 16.5 40 1.8 2.3 20 0.01 15 -- 5.6 Amperes Amperes S C C Volts Volts Volts mA Volts Volts kHz mA mA mS Volts 3 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM800HSA120 IntellimodTM Module Half Phase IGBT Inverter Output 800 Amperes/1200 Volts Electrical and Mechanical Characteristics, Tj = 25C unless otherwise specified Characteristics Symbol Test Conditions Min. Typ. Max. Units IGBT Inverter Sector Collector Cutoff Current ICES VFM VCE(sat) VCE = VCES, Tj = 25C VCE = VCES, Tj = 125C Diode Forward Voltage Collector-Emitter Saturation Voltage -IC = 800A, VD = 15V, VCIN = 5V VD = 15V, VCIN = 0V, IC = 800A, Tj = 25C VD = 15V, VCIN = 0V, IC = 800A, Tj = 125C Inductive Load Switching Times ton trr tC(on) toff tC(off) VD = 15V, VCIN = 0 ~ 5V VCC = 600V, IC = 800A Tj = 125C 0.5 -- -- -- -- 1.4 0.2 0.4 3.0 0.6 2.5 0.4 1.0 4.0 1.1 S S S S S -- 2.3 3.3 Volts -- -- -- -- -- -- 2.6 2.5 1.0 10 3.5 3.5 mA mA Volts Volts Thermal Characteristics Characteristic Junction to Case Thermal Resistance Symbol Rth(j-c)Q Rth(j-c)D Contact Thermal Resistance Rth(c-f) Condition Each IGBT Each FWDi Case to Fin Per Module, Thermal Grease Applied Min. -- -- -- Typ. -- -- -- Max. 0.027 0.045 0.022 Units C/Watt C/Watt C/Watt Recommended Conditions for Use Characteristic Supply Voltage Symbol VCC VD Input ON Voltage Input OFF Voltage PWM Input Frequency Minimum Dead Time VCIN(on) VCIN(off) fPWM tDEAD Condition Applied across C1-E2 Terminals Applied between V1-VC Applied between C1-VC Applied between C1-VC Using Application Circuit Input Signal Value 0 ~ 800 15 1.5 0 ~ 0.8 Units Volts Volts Volts 4.0 ~ VSXR Volts 5 ~ 20 4.0 kHz S 4 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM800HSA120 IntellimodTM Module Half Phase IGBT Inverter Output 800 Amperes/1200 Volts COLLECTOR-EMITTER SATURATON VOLTAGE CHARACTERISTICS (TYPICAL) SATURATON VOLTAGE CHARACTERISTICS (TYPICAL) OUTPUT CHARACTERISTICS (TYPICAL) 3.0 COLLECTOR-EMITTER SATURATION VOLTAGE VCE(sat), (VOLTS) SATURATION VOLTAGE, VCE(sat), (VOLTS) 3.0 COLLECTOR CURRENT, IC, (AMPERES) 800 Tj = 25oC VD = 17V 15 600 13 2.0 2.0 400 1.0 VD = 15V Tj = 25C Tj = 125C 1.0 IC = 800A Tj = 25C Tj = 125C 200 0 0 200 400 600 800 1000 COLLECTOR CURRENT, IC, (AMPERES) 0 0 13 15 17 SUPPLY VOLTAGE, VD, (VOLTS) 0 0 1.0 2.0 3.0 COLLECTOR-EMITTER VOLTAGE, VCEsat, (VOLTS) SWITCHING TIME VS. COLLECTOR CURRENT (TYPICAL) SWITCHING TIME VS. COLLECTOR CURRENT (TYPICAL) REVERSE RECOVERY CURRENT VS. COLLECTOR CURRENT (TYPICAL) SWITCHING TIMES, tc(on), tc(off), (s) toff REVERSE RECOVERY TIME, trr, (S) SWITCHING TIMES, ton, toff, (s) VCC = 600V VD = 15V Tj = 25C Tj = 125C Irr 100 trr 102 100 ton 100 tc(off) tc(on) 10-1 VCC = 600V VD = 15V Tj = 25C Tj = 125C 101 VCC = 600V VD = 15V Tj = 25C Tj = 125C 10-1 102 103 COLLECTOR CURRENT, IC, (AMPERES) 103 10-1 101 102 COLLECTOR CURRENT, IC, (AMPERES) 103 10-2 102 103 COLLECTOR CURRENT, IC, (AMPERES) 100 104 DIODE FORWARD CHARACTERISTICS 103 DIODE FORWARD CURRENT,-IE, (AMPERES) VD = 15V Tj = 25C Tj = 125C 102 101 0 1.0 2.0 3.0 DIODE FORWARD VOLTAGE, VEC, (VOLTS) REVERSE RECOVERY CURRENT, Irr, (AMPERES) 101 101 101 103 5 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM800HSA120 IntellimodTM Module Half Phase IGBT Inverter Output 800 Amperes/1200 Volts TRANSIENT THERMAL IMPEDANCE CHARACTERISTICS (IGBT) TRANSIENT IMPEDANCE, Zth(j-c), (NORMALIZED VALUE) TRANSIENT THERMAL IMPEDANCE CHARACTERISTICS (FWDi) TRANSIENT IMPEDANCE, Zth(j-c), (NORMALIZED VALUE) 101 101 100 100 10-1 10-1 10-2 SINGLE PULSE STANDARD VALUE = Rth(j-c)Q = 0.027C/W 10-2 SINGLE PULSE STANDARD VALUE = Rth(j-c)D = 0.045C/W 10-3 10-3 10-2 10-1 TIME, (s) 100 10 1 10-3 10-3 10-2 10-1 TIME, (s) 100 10 1 OVER CURRENT TRIP LEVEL VS. SUPPLY VOLTAGE (TYPICAL) OVER CURRENT TRIP LEVEL VS. TEMPERATURE DEPENDENCY (TYPICAL) FAULT OUTPUT PULSE WIDTH % (NORMALIZED) FAULT OUTPUT PULSE WIDTH VS. TEMPERATURE (TYPICAL) 1.2 OVER CURRENT TRIP LEVEL % (NORMALIZED) OVER CURRENT TRIP LEVEL % (NORMALIZED) Tj = 25C 1.4 1.2 1.2 1.0 1.0 1.0 0.8 0.8 0.8 VD = 15V VD = 15V 0 0 13 15 17 SUPPLY VOLTAGE, VD, (VOLTS) 0 20 100 180 JUNCTION TEMPERATURE, Tj, (C) 0 20 100 180 JUNCTION TEMPERATURE, Tj, (C) CONTROL SUPPLY VOLTAGE TRIP-RESET LEVEL TEMPERATURE DEPENDANCY (TYPICAL) 15 UV TRIP-RESET LEVEL, UVt, UVr, (VOLTS) VD = 15V UVt UVr 13 11 0 20 100 180 JUNCTION TEMPERATURE, Tj, (C) 6 |
Price & Availability of PM800HSA120
 |
|
|
|
|
All Rights Reserved © IC-ON-LINE 2003 - 2022 |
| [Add Bookmark] [Contact Us] [Link exchange] [Privacy policy] |
|
Mirror Sites : [www.datasheet.hk]
[www.maxim4u.com] [www.ic-on-line.cn]
[www.ic-on-line.com] [www.ic-on-line.net]
[www.alldatasheet.com.cn]
[www.gdcy.com]
[www.gdcy.net] |